NPR

Other Massey Mines Showed A Pattern Of Violations

Massey Energy CEO Don Blankenship arrives near the Upper Big Branch Mine in Montcoal, W.Va., where 29 miners died in an explosion. An NPR inquiry has found that Massey operates 10 underground coal mines with injury rates that exceed the national rate. (Getty Images)

An NPR News Investigation shows that the Upper Big Branch mine in West Virginia is not the only Massey Energy mine with a litany of safety violations, citations and fines.

Twenty-nine miners died last week in an explosion at the Upper Big Branch mine. Federal mine safety records document repeated safety problems at that mine. Now, NPR's analysis of federal records indicates a similar pattern at nine other Massey mines in Virginia, West Virginia and Kentucky.

NPR reviewed 2009 safety inspection records available from the Mine Safety and Health Administration for all 35 active underground coal mines owned by Massey Energy.

Four Massey mines had injury rates more than twice the national rate last year. The national rate is 4.03 injuries per 200,000 worker hours. Massey's Tiller No. 1 mine in Tazewell, Va., had the company's highest injury rate at 9.78. The other high-injury mines are Slip Ridge Cedar Grove (9.18) in Raleigh, W.Va., M 3 Energy Mining's No. 1 (8.86) in Pike County, Ky., and Solid Energy Mining's Mine No. 1 (8.49), which is also in Pike County.

Together last year, the 10 Massey mines with above-average injury rates received 2,400 safety citations.

Challenging Citations, Delaying Fines

Massey's long list of citations has some wondering whether the federal mine safety inspection system works.

"Part of the strategy by the mine operators [is], 'Well, we're going to contest everything,' " says Bruce Dial, a mine safety consultant who spent 24 years as a federal mine inspector and inspection trainer.

Dial is referring to the citations and fines leveled by federal inspectors. In the past four years, he says, in the wake of the Sago Mine disaster in West Virginia, inspections, citations and fines increased. Challenging the citations delays the payment of fines.

"It takes so long to get [citations] through the review commissions, they don't end up paying fines until it's three, four, five years down the road," he says.

In fact, 16,000 citation appeals are pending right now, and they're worth millions in fines. Massey Energy alone, according to NPR's analysis, has had more than $7.6 million in fines. That's over five years at those 10 high-injury mines. The company has paid just $2.3 million of that amount so far.

Massey did not respond to NPR's request for comment but said in a statement last week that its rate of violations (per day of inspection) at its Upper Big Branch mine is consistent with the national average.

That's not true, says Ellen Smith, owner of Mine Safety and Health News.

"The industry average is actually 0.71, and that particular mine has 0.94 violations per inspection day," Smith says. "So that mine is about 30 percent higher than the average underground bituminous coal mine."

A Question Of Liability

Smith believes one weakness in the system is the issue of liability for safety problems. Right now, she says, mine supervisors, foremen and mine companies as a whole can face criminal penalties for serious safety violations. That doesn't apply to company presidents or CEOs who were not directly involved in violations but who may have put productivity before safety.

"There will be a different safety culture if they know that there's a chance that they might spend six months in jail or they might have charges personally brought against them," Smith says. "But at this point there is nothing in the law that would allow that to happen."

The law does permit the federal Mine Safety and Health Administration to shut down a mine if there's a pattern of serious violations. But that kind of drastic action is rare. The agency declined to comment for this story, saying top officials were traveling to a memorial service for the miners killed last week.

Dennis O'Dell, health and safety director for the United Mine Workers union, compares the safety inspection system to driving drunk, but without the threat of a suspended license.

"I can drive, drink, I get pulled over, contest it, drive, drink, get pulled over and contest it until eventually I kill somebody or kill myself," he says. "And that's what's going on in the mining [industry]. And until we fix that, we're going to continue [to have] those operators who 'drive, drink and kill.' "

A 'Positive Incentive' To Contest Sanctions

Mining companies say they have to challenge citations because the fines are far higher and sanctions more serious since the Sago Mine disaster in 2006. Before the changes, mine operators could negotiate with federally appointed mediators who could reduce fines and limit sanctions, according to Luke Popovich, a spokesman for the National Mining Association, an industry group.

"When they removed this opportunity to contest [citations and fines] at a lower level, that created a positive incentive for operators to contest them the only way they could," he says.

Some of Massey's safety violations involve improper ventilation of methane gas and excessive buildup of coal dust, precisely the conditions that could have triggered last week's deadly explosion. But no cause is known for certain yet; the investigations are just getting under way.

Meanwhile, as recovery crews prepared Monday to remove the last of the bodies from the Upper Big Branch mine, S&P Equity Research issued a rosy financial review of the mine disaster's impact on Massey Energy's bottom line.

"We believe that the financial impact of the Upper Big Branch mine tragedy to Massey Energy will be immaterial," S&P Equity reported. "Our opinion is based on our analysis of industry mining accidents, Massey's indemnification to litigation via insurance, and our belief that the company has ample capacity to mitigate most of the 1.6 million tons of production that was expected to be sold from Upper Big Branch."

S&P then advised that Massey Energy is again a good buy for investors.

Copyright 2014 NPR. To see more, visit http://www.npr.org/.

Transcript

STEVE INSKEEP, host:

It's MORNING EDITION from NPR News. Good morning, Im Steve Inskeep.

RENEE MONTAGNE, host:

And Im Renee Montagne.

An NPR News investigation has found that the site of that deadly coal mine explosion in West Virginia last week isnt the only Massey Energy mine with safety concerns.

Nine other Massey coal mines had high injury rates last year. Four had injury rates more than twice the national rate, as NPR's Howard Berkes reports.

HOWARD BERKES: The NPR News analysis shows that Massey Energy's litany of safety violations, citations and fines goes beyond the Upper Big Branch Mine, where 29 miners died last week in the deadliest mine disaster in 40 years.

Upper Big Branch is among 10 Massey mines cited for safety problems last year more than 2,400 times, according to federal mine safety records. And Massey's long list of citations has some wondering whether the federal inspection system works.

Mr. BRUCE DIAL (Owner, Dial Mine Safety): Part of the strategy - I'd guess you'd want to call it - by the mine operators are, well, we're going to contest everything.

BERKES: Bruce Dial is a mine safety consultant and veteran federal inspector. In the last four years, he says, in the wake of the Sago Mine disaster, inspections, citations and fines increased.

Mr. DIAL: And it takes so long to get it through the review commissions, they don't end up paying fines until it's - oh, three, four, five years down the road.

BERKES: In fact, 16,000 citation appeals are pending, worth millions in fines. Massey Energy alone had more than $7 million in fines in the last five years at its high-injury mines, and it's paid less than a third of the fines so far.

Massey did not respond to NPR's request for comment, but said in a statement last week that its rate of violations at Upper Big Branch is consistent with the national average.

That's not true, according to Ellen Smith of "Mine Safety and Health News."

Ms. ELLEN SMITH (Editor, "Mine Safety and Health News): The industry average is actually .71, and that particular mine has a .94 violations per inspection day. So that mine is about 30 percent higher than the average, underground, bituminous coal mine.

BERKES: Smith thinks the problem lies in liability. Right now, she says, mine supervisors, foremen and mine companies as a whole can face criminal penalties for serious safety violations - but not company presidents or CEOs.

Ms. SMITH: There will be a different safety culture if they know that there's a chance that they might spend six months in jail, or they might have charges personally brought against them. But at this point, there is nothing in the law that would allow that to happen.

BERKES: The law does permit the Mine Safety and Health Administration to shut down a mine if there's a pattern of serious violations. But that kind of drastic action is rare. The agency also declined comment for this story, saying top officials were traveling to a memorial service for the miners killed last week.

Dennis O'Dell, of the United Mine Workers Union, compares the safety inspection system to driving drunk but without the threat of a suspended license.

Mr. DENNIS O'DELL (Health and Safety Director, United Mine Workers Union): And I can drive, drink. Ill get pulled over, contest it, until eventually I kill somebody or kill myself. And that's what's going on in the mining. Until we fix that, we're going to continue - those operators to drive, drink and kill.

BERKES: Mining companies say they have to challenge citations because the fines are far higher now. And before recent changes, they could negotiate reduced fines and sanctions with federally appointed mediators. Thats according to Luke Popovich of the National Mining Association.

Mr. LUKE POPOVICH (Spokesman, National Mining Association): When they removed an opportunity to contest these at a lower level, that created a positive incentive for operators to contest them the only way they could.

BERKES: Some of Massey's safety violations involve improper ventilation of methane gas, and excessive buildup of coal dust. And those are precisely the conditions that could have triggered last week's deadly explosion. But no cause is known for certain yet. The investigations are just getting under way.

And there was this news yesterday: As recovery crews prepared to remove the last of the bodies from the Upper Big Branch Mine, S&P Equity Research said the financial impact of this deadly mine disaster will be immaterial. Massey Energy stock, the advisory said, is again worth buying.

Howard Berkes, NPR News. Transcript provided by NPR, Copyright NPR.

Most Popular